07-29-2024, 12:59 PM
(07-29-2024, 12:26 PM)Bduck Wrote: As I was rummaging around in the garage looking to work a project, noticed a very noticeable odor of sulfur. Walking by my boat I usually check the onboard charger for the green lights. Number 1 was solid red & number 2 was flashing yellow. So I unplugged the charger which maintained an AGM on #1 and a wet cell on #2. I would get around to troubleshooting a little later after I get a couple of things done. 2hrs later I noticed the sulfur odor was getting stronger as I walked thru the garage, thankfully a breeze was blowing to air out the garage. My immediate attention now is drawn to the boat batteries, when opening battery compartment panel, I could hear the wet cell boiling. The AGM was supplying power to it continuing the boil. I then shutdown batt switch to off and disconnected the wet cell batt finding this batt was too hot to physically to touch. Once I got it removed, I took an infrared digital temperature reader finding batt temp was 171°F. This had disaster written all over it if it had gone any further sitting in the boat. This was an Interstate Costco battery I bought 6yrs ago and replaced with another AGM. This is my last AGM upgrade I was awaiting to do but not at the expense of a battery meltdown. My diesel truck takes 2 AGM's, Caddy Escalade & Buick took 1ea. I was sold long ago on AGM with final upgrade made, $$$$'s but well worth it.
Wow, that sounds scarry, just thinking about what could have happened if you did not catch it when you did. Do you think it could have exploded? Just curious, I know many folks leave their battery plugged in, to maintain their batteries when not in use but I've always been afraid of this happening, so I only keep mine plugged in until it is charged, then I unplug it and the day before I'm planning on taking the boat out again, I plug it in to make sure they a topped off.